'Cow power' turning turns manure and food waste into electricity in England

Washington, January 23 (ANI): Waste from the cows and food products are used to produce gas to power electric generators in a city in England, it has been revealed.

John Wintle monitors the engine inside the control room, where gas produced by mixing cow manure and food waste powers a generator and produces 5.2 million kilowatt-hours of electricity, at the Stonyvale Farm in Exeter.

Every day in rural Penobscot County, a large dairy farm harnesses clean-burning gas from cow manure and food waste, and it generates enough electricity to power 800 homes continuously.

The process, commonly known as cow power, has the potential to earn the facility $800,000 a year. It also creates byproducts-animal bedding and a less-odorous fertilizer-that save the farm about 100,000 dollars a year.

Cow power is more consistent than solar and wind energy, and it eliminates greenhouses gases that otherwise would enter the atmosphere.

For the past 13 months, Exeter Agri-Energy has been combining cow manure and industrial food waste at this location, the Morning Sentinel reported.

In its first year, the company generated 5,200 megawatt-hours for the grid, which earned the farm about 520,000 dollars from Bangor Hydro Electric. Now that the kinks have been worked out, the facility is on track to produce about 8,000 megawatt-hours a year. At 10 cents per kilowatt hour, that's 800,000 dollars.

The project was installed in four months beginning in August 2011. It cost 5.5 million dollars and received 2.8 million dollars in grants from Efficiency Maine, the U.S. Department of Agriculture and the U.S. Treasury Department.

The facility is a subsidiary of the Foglers' Stonyvale Farm, which hosts the project on its land.

Stonyvale also supplies the system with 20,000 gallons of raw cow manure every day.

The manure, which is produced by 1,800 cows, is plowed from the barn floors by a skid steer and diverted into a pump house. From there, the manure is pumped about 1,000 feet through underground pipes to Exeter Agri-Energy, where it enters the facility's anaerobic digesters-two silolike containers that each hold about 400,000 gallons of manure and food waste.

The food waste arrives nearly every day in an 8,000-gallon tanker truck. The waste comes from grease traps and food processors throughout New England and is delivered by a subcontractor. From the trucks, the waste is pumped into holding tanks, where it flows into the digesters and mixes with the manure.

The digesters are heated to 104 degrees, which creates optimal conditions for the bacteria that are naturally present in cow manure. As the bacteria feed and multiply, the mixture exudes biogas-about 60 percent methane and 40 percent carbon dioxide.

As the gas pressure builds, the containers' rubber tops expand like balloons and give the containers a domelike appearance. When pressure is sufficient, gas travels through pipes to a 1-megawatt generator.

The generator runs almost constantly throughout the year, except during maintenance periods. The exhaust leaves the generator through a short stainless steel stack, about the size of an exhaust pipe on a farm tractor.

Travis Fogler, operations manager for Stonyvale Farm, said the gas burns cleanly.

At the same time, spent material is pumped out of the containers, where it passes through a mechanical liquid separator. Plant fibres that aren't broken down during the anaerobic digestion process are separated from the water and reused.

All day long, the fibres churn out of the machine in bone-dry clumps that fall into large piles that are used for cow bedding or compost.

The liquid from the separator is pumped back to the farm, where it spills into lagoons that once held raw manure. The liquid contains all the same fertilizing nutrients found in raw manure, but it's better.

The liquid is easier to spread on fields than manure; plants absorb its nutrients more easily and it is virtually odourless, said Wintle.

Those two byproducts save the farm about 100,000 dollars a year, Fogler said.

The greatest savings are found in fertilizer costs. It's not that they produce more fertilizer; they can just use more of what they have. (ANI)

Matches

MORE TOP STORIES TODAY

Bangalore lose nerve, lose game

Bangalore lose nerve, lose game

IPL 7, GAME 11—Vinay's over, Lynn's catch turns last-over finish in KKR's favour. More »

Boycotting IPL will not save cricket

Boycotting IPL will not save cricket

Boycotting the IPL as a means of protest against the grime in the game may not yield the desired results. More »

Jadeja spins out Rajasthan in close chase

Jadeja spins out Rajasthan in close chase

IPL 7, GAME 10—Chennai beat Rajasthan by 7 runs after last-over scare. More »

Gambhir a knock away from striking form - KKR coach

Gambhir a knock away from striking form - KKR coach

Gautam made an eight-ball duck in the opening game against Mumbai and in the second game against Delhi, he lasted only half those balls. More »

Rivals say Srini group delaying BCCI special general meeting

Rivals say Srini group delaying BCCI special general meeting

The group opposed to Srinivasan alleged that since BCCI secretary Sanjay Patel belongs to the president’s group, he was intentionally delaying the SGM… More »

April 24: A legend is born

As Sachin Tendulkar turns 41 - here's a look at some offbeat moments from the Master Blaster's innings. More »

Cleaning up the game starts with fans

Cleaning up the game starts with fans

... because, as recent events reveal, the BCCI has little intention of doing it. More »

SL in 'difficult place' after Farbrace exit

SL in 'difficult place' after Farbrace exit

Sri Lanka depart for assignments in Ireland and England in two weeks, and Sanath Jayasuriya suggested Marvan Atapattu would be interim head coach for those… More »

Chandimal axed as T20 captain

Chandimal axed as T20 captain

Sri Lanka's cricket selectors on Wednesday sacked Dinesh Chandimal as Twenty20 captain and replaced him with Lasith Malinga, while Angelo Mathews was… More »

Vithanage, Priyanjan get T20 call-ups

Vithanage, Priyanjan get T20 call-ups

Herath has been rested, while the team will be without the veteran pair of Mahela Jayawardene and Kumar Sangakkara, who retired from T20 internationals… More »

'BCCI should have picked panel with care'

'BCCI should have picked panel with care'

Dalmiya said that it was the first time that the BCCI had been faced with a situation where the apex court had hauled up the Board and it should have acted… More »

Farbrace is England's assistant coach

Farbrace is England's assistant coach

The ECB continued the restructuring of the England coaching set-up on Wednesday by announcing the appointment of Paul Farbrace as assistant coach. More »

SC asks Mudgal committee to continue

SC asks Mudgal committee to continue

Mukul Mudgal has communicated to the court his willingness to take up the investigation and has been asked to specify the terms and modalities on April… More »

Sri Lanka players resolve pay dispute

Sri Lanka players resolve pay dispute

The pay dispute between Sri Lanka Cricket and its 13 contracted players ended on Wednesday when the latter agreed to accept 10 percent of the participation… More »

Hope to be fit for next game - Pietersen

Hope to be fit for next game - Pietersen

With two heavy defeats at the hands of Bangalore and Chennai, Daredevils currently languish near the bottom of the table. More »

'SC decision could hurt BCCI's status'

'SC decision could hurt BCCI's status'

The Supreme Court prefers that the Justice Mudgal panel further investigate the IPL corruption scandal. More »

Mudgal panel drops bombshell in court

Mudgal panel drops bombshell in court

The Mukul Mudgal probe committee dropped a bombshell in the Supreme Court on Tuesday by making a sensational claim that it was forced to stop audio recording… More »

Perfect Punjab trounce Hyderabad

Perfect Punjab trounce Hyderabad

IPL7, GAME 9—Maxwell (95, 43b), Balaji (4-13) set up 72-run win. More »

Have the ECB played an unfair game?

Have the ECB played an unfair game?

Money talks, but it is in light of this ICC shakeup that the ECB's act of soliciting of another team's coach deteriorates from free-market aggression to… More »

Farbrace quits for England post

Farbrace quits for England post

He will assist Peter Moores who was unveiled as the new England coach on Saturday. More »

Moin appointed to manage Pakistan team

Moin appointed to manage Pakistan team

Pakistan on Monday reappointed Moin Khan as chief selector and manager of the national team, a week after fellow former captain Rashid Latif turned down… More »

Chennai smash Delhi for first win

Chennai smash Delhi for first win

IPL7, MATCH 8—Raina-led middle order, superlative catching give CSK a 93-run win. More »

'BCCI reputation lowest in 80 years'

'BCCI reputation lowest in 80 years'

The former BCCI president says he was "disillusioned" by the happenings at the emergent working committee meeting on Sunday. More »

Injured Bravo to miss rest of IPL

Injured Bravo to miss rest of IPL

Dwayne Bravo is set to be sidelined for at least four weeks due to a shoulder problem. Bravo sustained the injury when attempting a catch on the boundary… More »